頗爾HC8314FDZ39H精油濾芯
頗爾HC8314FDZ39H精油濾芯
頗爾HC8314FDZ39H精油濾芯
頗爾HC8314FDZ39H精油濾芯
一、油氣分離器濾芯
油氣分離元件是決定空壓機壓縮空氣品質的關鍵部件，高質量的油氣分離元件不僅可保證壓縮機的高效率工作，且濾芯壽命可達數千小時。從壓縮機頭出來的壓縮空氣夾帶大大小小的油滴。大油滴通過油氣分離罐時易分離，而小油滴（直徑1um以下懸浮油微粒）則必須通過油氣分離濾芯的微米及玻纖濾料層過濾。油微粒經過濾材的擴散作用，直接被濾材攔截以及慣性碰撞凝聚等機理，使壓縮空氣中的懸浮油微粒很快凝聚成大油滴，在重力作用下油集聚在油分芯底部，通過底部凹處回油管進口返回機頭潤滑油系統，從而使壓縮機排出更加純凈無油的壓縮空氣。壓縮空氣中的固體粒子經過油分芯時滯留在過濾層中，這就導致了油分芯壓差（阻力）不斷增加。隨著油分芯使用時間增長，當油分芯壓差達到0.08到0.1Mpa時，濾芯必須更換，否則增加壓縮機運行成本（耗電）。
二、空氣過濾器濾芯
空壓機空氣濾芯用于空壓機進氣口處，除去空氣中的固體顆粒，保證系統清潔要求，空氣過濾器是濾除空氣塵埃污物的部件，過濾后的干凈空氣進入螺桿轉子壓縮腔壓縮。因螺桿機內部間隙只允許15u以內的顆粒濾出。如果空濾芯堵塞破損，大量大于15u的顆粒物進入螺桿機內循環，不僅大大縮短機油濾芯、油細分離芯的使用壽命，還會導致大量顆粒物直接進入軸承腔，加速軸承磨損使轉子間隙增大，壓縮效率降低，甚至轉子枯燥咬死。
1.空氣過濾器濾芯每星期保養一次，擰開壓蓋螺母，取出空濾芯，用0.2-0.4Mpa的壓縮空氣，從空氣過濾器濾芯內腔向外吹除在空濾芯外表面的塵埃顆粒，用干凈的抹布將空濾殼內壁上的贓物擦干凈。回裝空氣過濾器濾芯，注意空濾芯前端部的密封圈要與空濾殼內端面貼合嚴密。柴油動力螺桿機的柴油機進氣空濾芯的保養應與空壓機空濾芯同步進行，保養方法相同。
2.空氣過濾器濾芯正常情況1000-1500小時更換一次，環境特別惡劣的使用場所，如礦山、陶瓷廠、棉紡廠等，建議每500小時更換空氣濾芯。
3.清潔或更換空濾芯時，部件是必須一一合對，嚴防異物落入進氣閥。
4.平時須經常檢查進氣伸縮管有無破損、吸扁，伸縮管與空濾進氣閥的連接口有無松動、漏氣。如發現須及時修復、更換。
三、空壓機機油濾芯
空壓機機油濾芯是濾除空壓機專用油中的金屬顆粒、雜質等，保證機油循環系統的潔凈，保護主機安全運行。 工作時間通常為1500~2000小時，可根據環境狀況調整。機油過濾器堵塞報警設定值一般為1.0-1.4bar超期使用的危害：回油量不足，導致排氣溫度過高，縮短油和油分芯使用壽命；導致主機潤滑不足，嚴重縮短。
Baldwin PT23458, Inline Filters FB10023, FBWPT23458, FBW-PT23458Baldwin PT9216,
Donaldson P171505, FBO CR30/6, CR306, Filtrec R110T60B,
Inline Filters FH50647, FINFH50647, FIN-FH50647, SF Schupp HY18211Donaldson P176712, Filtration FTH6545,
Inline Filters FH50646, FINFH50646, FIN-FH50646, SF Schupp HY9626濾芯
Baldwin PT9418,濾芯 Caterpillar 1R0778, Inline Filters FB47641, FBWPT9418, FBW-PT9418, Luberfiner
LP560HEInline Filters FH50039, FINFH50039, FIN-FH50039, Manitou 746308, SF Schupp HY90604
Donaldson P173041, Fairey Arlon 370L222A, 370-L-222A, Fleetguard HF30233, Inline Filters FH50046,
FINFH50046, FIN-FH50046, Moxy 503071, Parker 7021010008, SF Schupp HY24054, HY24063
Argo P2.102312, P2.1023-12, P2.102312K, P2.1023-12K,濾芯 P2102312, P2102312K, Baldwin PT23138, Case
IHC 131775810, Deutz AG Fahr KHD 04417454, 4417454, Fendt F824100050010,
Fleetguard HF28864, Hengst E84H, Hifi Hirschi Jura SH52012, Inline Filters FH50051, FINFH50051, FIN-FH50051,
Mann 6750653256, H1059/2, H10592, New Holland 84407842,
SF Schupp HY10277, TRP 1535142, Vapormatic VPK5618, ZF 0501314626In-Line Filters FINFH50053, FIN-FH50053,
Parker FC5009.Q020.BS, FC5009Q020BS濾芯
Extec HF 1004, HF1004, Fleetguard HF35302, Inline Filters FH50056, FINFH50056, FIN-FH50056, Liebherr
510669708, 5106697-08, MP Filtri 8MF4003A10HBEP01, MF4003A10H, SF Schupp HY18473, Wismet WHE30431
Donaldson P171539, Inline Filters FDOP171539, FDO-P171539, FH50060, FINFH50060,濾芯 FIN-FH50060Donaldson
P171539, Inline Filters FDOP171539, FDO-P171539, FH50060, FINFH50060, FIN-FH50060
Fleetguard ST1588, Inline Filters FH50073, FINFH50073, FIN-FH50073, Mahle Knecht PI8545DRG100, SF Schupp
HY15090 HY15090, HY15090 HY15090, Woodgate WGH9972
Inline Filters FH50075, FINFH50075, FIN-FH50075Case IHC 47131183, Donaldson 150TT07, P763415, Fil ML1452MG,
Fleetguard HF35517, Ford 471274, 47127431,
4712743121LUG06, Inline Filters FH50088,濾芯 FINFH50088, FIN-FH50088, Mann 6750657140, HD1053, New Holland
5198414, 84226260, SF Schupp HY12734, Steyr 47131184, Vapormatic VPK5561
Inline Filters FH50091, FINFH50091, FIN-FH50091, SF Schupp HY24101, Volvo 11119887Baldwin PT108HD, PT108-HD,
Bosch 1-457-429-117, 1-457-431-428, 9-457-201-810, Clark 3739460,
Fleetrite 濾芯LFR8596, Ford A730X-6731-T3A, Inline Filters FBW-PT108HD, FH50104, FINFH50104, FIN-FH50104,
Mahle Knecht EN259, Massey Ferguson 837695M91, 837695-M91, 973118-M1, Micro Pore PM813, Mopar
L345, Perkins 32588, Ryco R2061P, Sakura O5001, Savara 920181, 92018117Digoema DGMH5ACC6, Fairey Arlon
TXW5A5B, TXW5A6B, TXW5ACC6, TXW5AGDL6, Fleetguard HF35126, Hifi Hirschi Jura SH53135,
Inline Filters FH50118, FINFH50118, FIN-FH50118, MP Filtri 8MR2504A06AP01, MR2504A06A, Orenstein and Koppel
2268253, Parker 937760Q, Separation Technologies ST1774, SF Schupp HY24310,濾芯 Sofima
ERF24NFB, Stauff RA300E05B, Wismet WHE31234, WHY340258Hydac 0850R020MM/KBSFREE, 0850R020MM/-KB-SFREE,
0850R020MMKBSFREE, 0850R020ON/PO/KB, 0850R020ON/PO/-KB,濾芯
0850R020ONPOKB, 1278247, Inline Filters FH50131, FINFH50131, FIN-FH50131, SF Schupp HY13802Donaldson
P569533, Inline Filters FH50132, FINFH50132, FIN-FH50132, SF Schupp HY20222
Donaldson P569534, Hifi Hirschi Jura SH87504, Inline Filters FH50137, FINFH50137, FIN-FH50137, Pall
HC8300FWT39H, HC8300WT39HB45D, Parker 932006PARGELOE, SF Schupp HY20225
CJC PA5601325, Inline Filters FH50141, FINFH50141, FIN-FH50141, SF Schupp HY90925Atlas Copco 4653961,
Baldwin PT9253MPG, PT9253MPG, PT9253-MPG, Fairey Arlon TXW11CC10,濾芯 Filtrec R741G10,
Finn FFPAVL1111110, Fleetguard HF7965, Inline Filters FBWPT9253, FBW-PT9253, FH50143, FINFH50143,
FIN-FH50143, MP Filtri MR8501A10, SF Schupp HY2849, Woodgate WGTW11CC10
AC Delco PF342, Allis Chalmers 79170, 791702, 791707, 79174, AP Lockheed 574361, AP641, AP641A, APH3184A,
FH361, LK641, Baldwin P186, Case IHC 168743R91, 168743-R91, 169743R91, 169743-R91, 3074321R91, 3074321-R91,
392426C1, 392426-C1, Chrysler Dodge 1405639, 3116654, 濾芯Coopers Fiaam AZH014, G723, HEM6069, Crosland 447,
Donaldson P551221, Fiat 70079170, 70079174, Finn FFP201, Fleetguard HF6195, LF602, Fleetrite HFR86195, LFR8602, Fram C1659,
Greyfriars 697P, Harmo P241, Inline Filters FH50165, FINFH50165, FIN-FH50165, Kralinator L953, Leyland Daf BL 37H1434, Luberfiner
LP176, Mann H914, Massey Ferguson 1019235M1, 1019235M91, 1019235-M91, 1883318M1, 1883318-M1, 1883318M91, 1883318-M91, Motorcraft FH16,
Plessey 550/2/04944, 550/4/04944, 550204944, 550404944, Purolator Facet 38960, 39350, MF641A, P176, P7661, P7662, P7663, P776, P776SERIES,
PM2082, Ryco R2023P, R2075PA, Savara 92151117, Soparis CAP347, Tecfil P663, PH663, Tecnocar OP921, Vapormatic VPJ4501, Vauxhall GM 2381012,
5574746, 5574758, Wix 51430, Woodgate WGH6195, Yale 515283801, 5152838-01Baldwin PT9171, Filtrec WG196, Fleetguard HF35487, Inline Filters FH50172,
FINFH50172, FIN-FH50172, Liebherr 7001636, Mann H1266, SF Schupp HY16379, Woodgate WGH9128
Baldwin PT23003, Donaldson P171551, FBO CR250/1, CR2501, Filtration FTH6706, Inline Filters FH50177, FINFH50177, FIN-FH50177, MP Filtri MF4001P10NB, OMT CR221C10R, SF Schupp HY18235
Inline Filters FH50178, FINFH50178, FIN-FH50178, Mahle Knecht 852239DRG60, SF Schupp HY15393
Inline Filters FH50186, FINFH50186, FIN-FH50186, Mahle Knecht 852939MIC10, SF Schupp HY15599Baldwin P204HD10, P204-HD10, Case IHC A63358, A66483, Clark 207930019, 207930-019, 887764, Donaldson P165132, Fram C1664, Harnischfeger 1045Z324, Inline Filters FBW-P204HD10,
FH50187, FINFH50187, FIN-FH50187, Koehring 84519, Napa 2115, Purolator Facet H40139, P139, PM6024, Vickers 228468, 919414, 922989, 923070KIT, 923117, 923118, OFM20, OFM200, OFM201, OFM202, OFM30, OFM300, OFM301, Yale 923070
濾芯AC Delco PF434, Baldwin P450, Case IHC 276259C91, 276259-C91, Inline Filters FH50188, FINFH50188, FIN-FH50188, Luberfiner LP259, Motorcraft FH29, Purolator Facet 6938015
Filtrec RLR320E10B, Inline Filters FH50191, FINFH50191, FIN-FH50191, Internormen 01.E320.10VG.16.S.P, 01E32010VG16SP, SF Schupp HY9432
Inline Filters FH50196, FINFH50196, FIN-FH50196, Internormen 01/E950/10P/10EP, 01E95010P10EP, 17.950P10J000P, 17.950P10-J00-0-P, 17950P10J000P, 300297, SF Schupp HY14265, Wismet WHE28701
Belos 8447901, Inline Filters FH50198, FINFH50198, FIN-FH50198, Kaercher 69897730, SF Schupp HY90551, Stiga 8447901
AC Delco PF2117, Baldwin P454, Case IHC 507809C91, 507809-C91, Donaldson P552419, Ford D0HZ3C602A, D0HZ-3C602-A, D0HZ3C602B, D0HZ-3C602-B, D9HZ3C602A, D9HZ-3C602-A, D9HZ3C602B, D9HZ-3C602-B, Fram C7571, Inline Filters FH50199, FINFH50199, FIN-FH50199, Vauxhall GM 25014780, White 384905026, 38-4905026, Wix 51464
Donaldson P174292, Filtrec DMD0015E10B, DMD0015L10B, Finn FC5012Q010BS, Fleetguard ST1408, Hydac 2150D10BN, Inline Filters FH50211, FINFH50211, FIN-FH50211, Internormen 04.PI3115.10VG.16.E.O, 04PI311510VG16EO, 301039, Krauss Maffei 643001, Mahle Knecht 9640512151, PI3115PS10, PI3115SMX10, PI3115SMX10(KM), PI3115SMX10KM, Mann HD929, Pall HC2235FKS6, Parker PR2855, PR2855Q,
SF Schupp HY15027, Sofima SPI3115FD11, Stauff SL045E10B, SL-045E10B, Woodgate WGH9941
Baldwin PT23472, Hifi Hirschi Jura SH63057, Inline Filters FH50217, FINFH50217, FIN-FH50217, MP Filtri 8SF510M90, SF510M90, SF Schupp C2510/M90, C2-510/M90, C2510M90, HY18017
Inline Filters FH50222, FINFH50222, FIN-FH50222, Internormen 312440, SF Schupp 312440ALT, 312440-ALT
Hy Pro HP97RNL1410MB, HP97RNL14-10MB, Inline Filters FH50225, FINFH50225, FIN-FH50225, SF Schupp HP97RNL1410MB
Baldwin H8001, H9001, Caterpillar 3I0593, 3I0618, Donaldson P164215, P164574, Fairey Arlon R830H0806A, Filtrec R430G06, Fleetguard HF30060, HF35183, HF7001, HF7002, Fleetrite HFR830060, HFR835183, HFR87001, HFR87002, Greyfriars GHF7137, Hydac H83008005BN, Inline Filters FH50229, FINFH50229, FIN-FH50229, Luberfiner
LH4239, Mann HD1666/1, HD16661, Orenstein and Koppel 8024582, Pall HC8300FDN8H, HC8300FDS8H, HC8300FKN8H, HC8300FUN8H, HC8300FUS8H, Parker 927633, 927661, 927663, PR2797, Purolator Facet 8300EAL062N1, 8300EAL122N1, 9314003, 9326796, SF Schupp HY20200, Stauff SP100E05B, Swift SF830086UM, SF8300-8-6UM, Terex 15265318, Vauxhall GM 9398179, Western E0410B1U10, Woodgate WGPN8308
Bosch FJSJ34P1Z, Inline Filters FH50236, FINFH50236, FIN-FH50236, SF Schupp HY9397Baldwin PT9352, Donaldson P764679, Fleetguard HF28925, Hitachi 4210224, 4385915, Inline Filters FH50604, FINFH50604, FIN-FH50604, JCB 335/G0387, 335G0387, John Deere TH110133, SF Schupp HY9351
Hydac 0330D100W/HC, 0330D100WHC, Inline Filters FH50608, FINFH50608, FIN-FH50608, SF Schupp HY13522
Baldwin PT9357, Filtration FTH6799, Fleetguard HF35449, Inline Filters FH50609, FINFH50609, FIN-FH50609, Volvo 14509379
Baldwin PT9420MPG, PT9420-MPG, Fleetguard HF35512, Inline Filters FBW-PT9420MPG, FH50612, FINFH50612, FIN-FH50612, Komatsu 21W6041121, 21W-60-41121, Napa 7001, SF Schupp HY90322, Wix 557001, 57001, R55F20G
Hifi Hirschi Jura SH68045, Inline Filters FH50615, FINFH50615, FIN-FH50615, Liebherr 7019839, SF Schupp HY16116, HY16367
Fairey Arlon PXW5/20/B, PXW520B, In-Line Filters FINFH50618, FIN-FH50618Baldwin PT9315KIT, Digoema DGMH1412H31601, Donaldson P176945, Hifi Hirschi Jura SH55186, Inline Filters FH50621, FINFH50621, FIN-FH50621, Palfinger EA1412, SF Schupp HY9784, Woodgate WGH1783
Donaldson P170737, Fleetguard HF30078, Grove 02212647, Inline Filters FH50622, FINFH50622, FIN-FH50622, Liebherr 510666908, Pall HC8200FKN8Z, SF Schupp HY20150
Inline Filters FH50623, FINFH50623, FIN-FH50623, FMP8MF7501A10HBP01, FMP-8MF7501A10HBP01, MP Filtri 8MF7501A10HB, 8MF7501A10HBP01, MF7501A10HB, MF7501A10HB14SQ05847
Inline Filters FH50624, FINFH50624, FIN-FH50624, Liebherr 5106691, 510669108, SF Schupp HY12107Baldwin PT9248, Crosland 2243, Donaldson P760155, Filtrec WP292, Fleetguard HF7981, Greyfriars GHF7176,
Hifi Hirschi Jura SH50715, Inline Filters FH50634, FINFH50634, FIN-FH50634, Manitou 21967, 221174, New Holland 85807055, SF Schupp HY9210, HY9210/1, HY92101, Woodgate WGH1796, WGH9159
Hifi Hirschi Jura SH60123, Inline Filters FH50637, FINFH50637, FIN-FH50637, Linkbelt KHJ0738, SF Schupp HY90182
Bosch F026404003, Z4003, Digoema DGM/O67181, DGMO67181, Filtron 681N, OE681, Fleetguard HF35074,
